Chevrolet Cavalier

Documented records held locally from official US and Canadian sources. Each record shows its official identifier so it can be confirmed at the source; nothing here is a score or a prediction.

Vehicle coverage

Find your car

Choose a vehicle to see the official records held for it.

Coverage held for this vehicle

  • OFFICIAL ACTION 104 US Recalls
  • MANUFACTURER COMMUNICATION 4,097 Manufacturer Bulletins
  • INVESTIGATION 29 Investigations
  • CONSUMER REPORT 7,894 Consumer Complaints
  • CANADIAN RECALL 54 Canada Recalls

These are counts of distinct official records held locally. They are not combined into any score, and a record count is not a failure rate. A zero means no record is held here, not that none exists.

US Recalls

NHTSA Recall US

  • 09E025000 2009-05-11

    Recall 09E025000

    DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

    Recorded model years: 1998

  • 09E025000 2009-05-11

    Recall 09E025000

    DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

    Recorded model years: 1995

  • 09E025000 2009-05-11

    Recall 09E025000

    DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

    Recorded model years: 1999

Showing 3 of 104 records held. The full set is available from the official source named above.

Campaign applicability can depend on build date, equipment and market, and a remedy may already have been completed. Confirm any campaign against the official record using the VIN.

Manufacturer Bulletins

NHTSA Manufacturer Communication US

  • 11020816 2025-07-18

    PIP5601C

    This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

    Recorded model years: 2002

  • 11020816 2025-07-18

    PIP5601C

    This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

    Recorded model years: 2004

  • 11020816 2025-07-18

    PIP5601C

    This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

    Recorded model years: 2001

Showing 3 of 4,097 records held. The full set is available from the official source named above.

A manufacturer communication is service guidance issued to dealers. It is not a safety recall, and its existence does not mean this vehicle has the described condition.

Investigations

NHTSA Investigation US

  • EA07015 2007-11-01

    ENGINE STALLING - FUEL PUMP FAILURE

    ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR…

    Recorded model years: 2003

  • EA07015 2007-11-01

    ENGINE STALLING - FUEL PUMP FAILURE

    ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR…

    Recorded model years: 2003

  • PE07033 2007-06-28

    FUEL PUMP FAILURE

    AN ENGINEERING ANALYSIS HAS BEEN OPENED TO FURTHER INVESTIGATE THE SCOPE, FREQUENCY AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.GENERAL MOTORS (GM) HAS IDENTIFIED AN ISSUE WITH ACCELERATED MOTOR BRUSH WEAR IN THE FUEL PUMP ASSEMBLY OF MODEL YEAR (MY) 2001 THROUGH 2003 CHEVROLET VEHICLES THAT CAN CAUSE THE PUMP TO STOP OPERATING.GENERAL MOTORS INDICATED THAT PEROXIDE OR SULFUR, WHICH…

    Recorded model years: 2003

Showing 3 of 29 records held. The full set is available from the official source named above.

An investigation records that a regulator reviewed a suspected defect. It is not itself a finding of defect and not a recall.

Canada Recalls

Transport Canada Recall CA

  • 2004388 2004-10-29

    Transport Canada recall 2004388

    Certain vehicles were produced without the required dielectric grease being applied to the rear light bulb socket assemblies. Absence of the grease can result in electrical arcing between the light bulb major filament contact and the socket terminal that can render the stop and turn signal bulb inoperative. An inoperative rear turn signal lamp will not convey the driver's intention…

    Recorded model years: 2003

  • 2004388 2004-10-29

    Transport Canada recall 2004388

    Certain vehicles were produced without the required dielectric grease being applied to the rear light bulb socket assemblies. Absence of the grease can result in electrical arcing between the light bulb major filament contact and the socket terminal that can render the stop and turn signal bulb inoperative. An inoperative rear turn signal lamp will not convey the driver's intention…

    Recorded model years: 2003

  • 2004211 2004-07-06

    Transport Canada recall 2004211

    Certain vehicles do not comply with the requirements of CMVSS 209 - Seat Belt Assemblies, and CMVSS 210 - Seat Belt Assembly Anchorages. On some of these vehicles, the passenger-side rear safety belt may have been installed with an incorrect nut and bolt that may not withstand the loads required by the two standards. In a severe crash, the upper…

    Recorded model years: 2004

Showing 3 of 54 records held. The full set is available from the official source named above.

Canadian campaigns are recorded separately from US campaigns and do not imply one another.

Consumer Complaints

NHTSA Complaint US

7,894 complaint records in the dataset for this vehicle and year.

These are owner-submitted allegations, not confirmed defects. Counts are record counts in the dataset. No exposure denominator exists, so no failure rate or reliability score can be derived from them.

Back to the Chevrolet Cavalier page