2004 Chevrolet Monte Carlo

Documented records held locally from official US and Canadian sources. Each record shows its official identifier so it can be confirmed at the source; nothing here is a score or a prediction.

Vehicle coverage

Find your car

Choose a vehicle to see the official records held for it.

Coverage held for this vehicle

  • OFFICIAL ACTION 7 US Recalls
  • MANUFACTURER COMMUNICATION 478 Manufacturer Bulletins
  • INVESTIGATION 0 Investigations
  • CONSUMER REPORT 230 Consumer Complaints
  • CANADIAN RECALL 3 Canada Recalls

These are counts of distinct official records held locally. They are not combined into any score, and a record count is not a failure rate. A zero means no record is held here, not that none exists.

US Recalls

NHTSA Recall US

  • 15V701000 2015-10-26

    Recall 15V701000

    General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

    Recorded model years: 2004

  • 15V201000 2015-04-06

    Recall 15V201000

    General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18,…

    Recorded model years: 2004

  • 14V400000 2014-07-03

    Recall 14V400000

    This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model…

    Recorded model years: 2004

Showing 3 of 7 records held. The full set is available from the official source named above.

A further 21 records exist for the Chevrolet Monte Carlo where the source stated no model year. They are not counted above and appear on no year page.

Campaign applicability can depend on build date, equipment and market, and a remedy may already have been completed. Confirm any campaign against the official record using the VIN.

Manufacturer Bulletins

NHTSA Manufacturer Communication US

  • 11020816 2025-07-18

    PIP5601C

    This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

    Recorded model years: 2004

  • 11014455 2025-02-20

    PIP5358D

    This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

    Recorded model years: 2004

  • 11009156 2024-10-25

    PIP4723J

    This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

    Recorded model years: 2004

Showing 3 of 478 records held. The full set is available from the official source named above.

A further 1,260 records exist for the Chevrolet Monte Carlo where the source stated no model year. They are not counted above and appear on no year page.

A manufacturer communication is service guidance issued to dealers. It is not a safety recall, and its existence does not mean this vehicle has the described condition.

Investigations

NHTSA Investigation US

No matching records were found in the currently integrated dataset. This does not mean none exist for this vehicle — always check the official source using the VIN.

See all model years Go to the Chevrolet Monte Carlo page

A further 7 records exist for the Chevrolet Monte Carlo where the source stated no model year. They are not counted above and appear on no year page.

An investigation records that a regulator reviewed a suspected defect. It is not itself a finding of defect and not a recall.

Canada Recalls

Transport Canada Recall CA

  • 2015501 2015-10-23

    Transport Canada recall 2015501

    On certain vehicles equipped with a 3.8L engine, degradation of the front rocker cover gasket may result in eventual oil seepage. Under hard braking, drops of engine oil may be deposited on the exhaust manifold. If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and, in some instances,…

    Recorded model years: 2004

  • 2014284 2014-07-03

    Transport Canada recall 2014284

    On certain vehicles, a defect in the ignition switch could allow the switch to move out of the "run" position if the key ring is carrying added weight or the vehicle goes off-road or is subjected to some other jarring event. If this were to occur, engine power, power steering and power braking would be affected, increasing the risk of…

    Recorded model years: 2004

  • 2004198 2004-06-16

    Transport Canada recall 2004198

    On certain vehicles, two bolts that attach the front brake caliper to the steering knuckle on the left and right front wheel assemblies were not tightened adequately. If too much movement occurs between the caliper bracket and knuckle, the bolt(s) may back out or fracture. Depending on whether one or both bolts back out or fracture, the result can be:…

    Recorded model years: 2004

A further 18 records exist for the Chevrolet Monte Carlo where the source stated no model year. They are not counted above and appear on no year page.

Canadian campaigns are recorded separately from US campaigns and do not imply one another.

Consumer Complaints

NHTSA Complaint US

230 complaint records in the dataset for this vehicle and year.

Outcomes stated in those reports

  • reports mentioning a crash 5
  • reports mentioning a fire 11
  • reported injuries 9

Outcomes as stated by the person who filed the report. They are not verified, not adjudicated, and carry no exposure denominator, so they cannot be turned into a rate.

By system

  • Electrical system151 (54.9%)Official recall records for this system: 4, covering model years 2001–2007.
  • Engine29 (10.5%)Official recall records for this system: 7, covering model years 1996–2004.
  • Steering16 (5.8%)Official recall records for this system: 4, covering model years 1997–2007.
  • Brakes14 (5.1%)Official recall records for this system: 5, covering model years 1995–2004.
  • Lights12 (4.4%)
  • Equipment & accessories6 (2.2%)Official recall records for this system: 1, covering model years 2003.
  • Speed control & accelerator6 (2.2%)
  • Seats5 (1.8%)

Other / uncategorized: 6 classifications (2.2%) were not assigned to a specific system by the source. They are counted but not treated as an issue area.

A single report can name several systems, so these figures overlap and must not be added together — their sum is larger than the report total above.

A further 1,882 complaint records exist for this vehicle where the source stated no model year. They are not counted above and appear on no year page.

These are owner-submitted allegations, not confirmed defects. Counts are record counts in the dataset. No exposure denominator exists, so no failure rate or reliability score can be derived from them.

Back to the Chevrolet Monte Carlo page