2000 Ford Expedition

Documented records held locally from official US and Canadian sources. Each record shows its official identifier so it can be confirmed at the source; nothing here is a score or a prediction.

Vehicle coverage

Find your car

Choose a vehicle to see the official records held for it.

Coverage held for this vehicle

  • OFFICIAL ACTION 11 US Recalls
  • MANUFACTURER COMMUNICATION 206 Manufacturer Bulletins
  • INVESTIGATION 5 Investigations
  • CONSUMER REPORT 890 Consumer Complaints
  • CANADIAN RECALL 5 Canada Recalls

These are counts of distinct official records held locally. They are not combined into any score, and a record count is not a failure rate. A zero means no record is held here, not that none exists.

US Recalls

NHTSA Recall US

  • 06E067000 2006-08-01

    Recall 06E067000

    CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

    Recorded model years: 2000

  • 06E060000 2006-06-29

    Recall 06E060000

    CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

    Recorded model years: 2000

  • 06E056000 2006-06-13

    Recall 06E056000

    CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

    Recorded model years: 2000

Showing 3 of 11 records held. The full set is available from the official source named above.

A further 86 records exist for the Ford Expedition where the source stated no model year. They are not counted above and appear on no year page.

Campaign applicability can depend on build date, equipment and market, and a remedy may already have been completed. Confirm any campaign against the official record using the VIN.

Manufacturer Bulletins

NHTSA Manufacturer Communication US

  • 10177863 2020-07-13

    TSB 20-2233

    This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.

    Recorded model years: 2000

  • 10155551 2019-02-07

    TSB 19-2026

    Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition

    Recorded model years: 2000

  • 10156863 2019-02-07

    TSB 19-2026

    Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition

    Recorded model years: 2000

Showing 3 of 206 records held. The full set is available from the official source named above.

A further 1,518 records exist for the Ford Expedition where the source stated no model year. They are not counted above and appear on no year page.

A manufacturer communication is service guidance issued to dealers. It is not a safety recall, and its existence does not mean this vehicle has the described condition.

Investigations

NHTSA Investigation US

  • EA05015 2005-10-13

    WINDSHIELD LEAK CAUSES ELECTRIC FAILURES

    CONSUMERS ALLEGED THAT WHEN IT RAINED OR SNOWED, WATER LEAKED INTO THE VEHICLE AROUND THE WINDSHIELD.MOISTURE FLOWING THROUGH THE SEAL THAT SURROUNDS THE FRONT WINDSHIELD FOLLOWS A PATH THROUGH THE SEAL INTO THE GENERIC ELECTRONIC MODULE (GEM) AND FUSE BOX, AND MAY CAUSE THE ELECTRICAL COMPONENTS IN THE VEHICLE TO MALFUNCTION.OVERALL, THE NUMBER OF REPORTS ALLEGING WIPER FAILURES AND LIGHTING…

    Recorded model years: 2000

  • DP05005 2005-09-22

    SPARK PLUG EJECTION FROM CYLINDER HEAD

    ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED…

    Recorded model years: 2000

  • PE05033 2005-06-15

    ELECTRICAL SYSTEM FAILURE

    ODI HAS RECEIVED 39 REPORTS ALLEGING THAT WATER LEAKS AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS.FORD REPORTS THAT WATER ENTERING THE VEHICLE CAN WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM).THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING…

    Recorded model years: 2000

Showing 3 of 5 records held. The full set is available from the official source named above.

A further 21 records exist for the Ford Expedition where the source stated no model year. They are not counted above and appear on no year page.

An investigation records that a regulator reviewed a suspected defect. It is not itself a finding of defect and not a recall.

Canada Recalls

Transport Canada Recall CA

  • 2005028 2005-02-14

    Transport Canada recall 2005028

    On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: Initially as an interim repair, owners will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected.…

    Recorded model years: 2000

  • 2004164 2004-05-18

    Transport Canada recall 2004164

    Multiple source assertions are recorded for this identifier. Consult the official record for configuration-specific detail.

    Recorded model years: 2000

  • 2001204 2001-08-13

    Transport Canada recall 2001204

    Multiple source assertions are recorded for this identifier. Consult the official record for configuration-specific detail.

    Recorded model years: 2000

Showing 3 of 5 records held. The full set is available from the official source named above.

A further 64 records exist for the Ford Expedition where the source stated no model year. They are not counted above and appear on no year page.

Canadian campaigns are recorded separately from US campaigns and do not imply one another.

Consumer Complaints

NHTSA Complaint US

890 complaint records in the dataset for this vehicle and year.

Outcomes stated in those reports

  • reports mentioning a crash 55
  • reports mentioning a fire 199
  • reported injuries 43
  • reported fatalities 2

Outcomes as stated by the person who filed the report. They are not verified, not adjudicated, and carry no exposure denominator, so they cannot be turned into a rate.

By system

  • Electrical system219 (19.5%)Official recall records for this system: 11, covering model years 1997–2026.
  • Tires & wheels186 (16.5%)Official recall records for this system: 6, covering model years 1997–2008.
  • Engine137 (12.2%)Official recall records for this system: 8, covering model years 2020–2025.
  • Speed control & accelerator125 (11.1%)Official recall records for this system: 2, covering model years 1997–2002.
  • Visibility (glass, wipers, mirrors)74 (6.6%)Official recall records for this system: 33, covering model years 2000–2024.
  • Suspension65 (5.8%)Official recall records for this system: 5, covering model years 1997–2019.
  • Body & structure48 (4.3%)Official recall records for this system: 10, covering model years 1997–2024.
  • Powertrain (transmission & drivetrain)43 (3.8%)Official recall records for this system: 21, covering model years 1997–2023.

Other / uncategorized: 24 classifications (2.1%) were not assigned to a specific system by the source. They are counted but not treated as an issue area.

A single report can name several systems, so these figures overlap and must not be added together — their sum is larger than the report total above.

A further 9,283 complaint records exist for this vehicle where the source stated no model year. They are not counted above and appear on no year page.

These are owner-submitted allegations, not confirmed defects. Counts are record counts in the dataset. No exposure denominator exists, so no failure rate or reliability score can be derived from them.

Back to the Ford Expedition page