2002 Hyundai Santa Fe

US Recalls

NHTSA Recall US

• 14V435000 2014-07-18

  Recall 14V435000

  Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 “salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New…

  Recorded model years: 2002

• 09V123000 2009-04-16

  Recall 09V123000

  HYUNDAI IS RECALLING 83,355 MY 2001-2003 SANTA FE VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY…

  Recorded model years: 2002

• 03V520000 2003-12-18

  Recall 03V520000

  CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

  Recorded model years: 2002

Showing 3 of 4 records held. The full set is available from the official source named above.

A further 49 records exist for the Hyundai Santa Fe where the source stated no model year. They are not counted above and appear on no year page.

Campaign applicability can depend on build date, equipment and market, and a remedy may already have been completed. Confirm any campaign against the official record using the VIN.

Manufacturer Bulletins

NHTSA Manufacturer Communication US

• 11032523 2026-04-10

  DTN DL

  The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts.…

  Recorded model years: 2002

• 11032522 2026-04-10

  DTN DCS

  The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious…

  Recorded model years: 2002

• 11025476 2025-11-06

  25-BD-012H TSB

  This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for…

  Recorded model years: 2002

Showing 3 of 50 records held. The full set is available from the official source named above.

A further 745 records exist for the Hyundai Santa Fe where the source stated no model year. They are not counted above and appear on no year page.

A manufacturer communication is service guidance issued to dealers. It is not a safety recall, and its existence does not mean this vehicle has the described condition.

Investigations

NHTSA Investigation US

• EA08023 2008-10-28

  REAR TRAILING ARM CORROSION FAILURE

  IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA,…

  Recorded model years: 2002

A further 15 records exist for the Hyundai Santa Fe where the source stated no model year. They are not counted above and appear on no year page.

An investigation records that a regulator reviewed a suspected defect. It is not itself a finding of defect and not a recall.

Canada Recalls

Transport Canada Recall CA

• 2014322 2014-08-01

  Transport Canada recall 2014322

  On certain vehicles, the front suspension coil springs may be susceptible to corrosion. Over time, corrosion could cause the springs to fail, potentially damaging front tires and causing rapid air loss and/or tire failure, which could increase the risk of a crash causing injury and/or property damage. Correction: Dealers will inspect and replace coil springs as necessary. Additionally, a spring…

  Recorded model years: 2002

• 2009122 2009-04-23

  Transport Canada recall 2009122

  On certain vehicles operated in areas of heavy road salt usage (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador), road salt may cause internal corrosion of the rear trailing arms, which could lead to thinning or perforation of the trailing arm steel. In time, the trailing arms may fracture, which could result in a loss…

  Recorded model years: 2002

• 2003326 2003-12-10

  Transport Canada recall 2003326

  On certain vehicles, the wheel rims and the tire pressure labels do not comply with CMVSS 120. The rims do not contain the required markings and the tire pressure labels do not contain the rim size. Correction: Hyundai will provide owners with a corrected tire pressure label. Since the non-compliant wheel rims do not pose any safety risk, no corrective…

  Recorded model years: 2002

A further 50 records exist for the Hyundai Santa Fe where the source stated no model year. They are not counted above and appear on no year page.

Canadian campaigns are recorded separately from US campaigns and do not imply one another.

Consumer Complaints

NHTSA Complaint US

165 complaint records in the dataset for this vehicle and year.

Outcomes stated in those reports

• reports mentioning a crash 9
• reports mentioning a fire 2
• reported injuries 6

Outcomes as stated by the person who filed the report. They are not verified, not adjudicated, and carry no exposure denominator, so they cannot be turned into a rate.

By system

• Suspension62 (28.3%)Official recall records for this system: 5, covering model years 2001–2011.
• Brakes21 (9.6%)Official recall records for this system: 16, covering model years 2003–2018.
• Engine20 (9.1%)Official recall records for this system: 13, covering model years 2001–2026.
• Body & structure18 (8.2%)Official recall records for this system: 3, covering model years 2013–2021.
• Steering16 (7.3%)Official recall records for this system: 2, covering model years 2018.
• Speed control & accelerator15 (6.8%)
• Powertrain (transmission & drivetrain)14 (6.4%)Official recall records for this system: 10, covering model years 2010–2024.
• Electrical system11 (5.0%)Official recall records for this system: 13, covering model years 2001–2026.

Other / uncategorized: 4 classifications (1.8%) were not assigned to a specific system by the source. They are counted but not treated as an issue area.

A single report can name several systems, so these figures overlap and must not be added together — their sum is larger than the report total above.

A further 7,607 complaint records exist for this vehicle where the source stated no model year. They are not counted above and appear on no year page.

These are owner-submitted allegations, not confirmed defects. Counts are record counts in the dataset. No exposure denominator exists, so no failure rate or reliability score can be derived from them.