2000 Pontiac Sunfire

US Recalls

NHTSA Recall US

• 08E063000 2008-10-17

  Recall 08E063000

  DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE.…

  Recorded model years: 2000

• 07E021000 2007-03-12

  Recall 07E021000

  CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

  Recorded model years: 2000

• 04V036000 2004-01-27

  Recall 04V036000

  ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.

  Recorded model years: 2000

A further 21 records exist for the Pontiac Sunfire where the source stated no model year. They are not counted above and appear on no year page.

Campaign applicability can depend on build date, equipment and market, and a remedy may already have been completed. Confirm any campaign against the official record using the VIN.

Manufacturer Bulletins

NHTSA Manufacturer Communication US

• 11009156 2024-10-25

  PIP4723J

  This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

  Recorded model years: 2000

• 11007744 2024-09-12

  PIT5099H

  This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

  Recorded model years: 2000

• 11007743 2024-09-12

  PIT5099H

  This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

  Recorded model years: 2000

Showing 3 of 369 records held. The full set is available from the official source named above.

A further 877 records exist for the Pontiac Sunfire where the source stated no model year. They are not counted above and appear on no year page.

A manufacturer communication is service guidance issued to dealers. It is not a safety recall, and its existence does not mean this vehicle has the described condition.

Investigations

NHTSA Investigation US

• EA02028 2002-09-30

  ERRATIC FUEL GAUGE

  ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION…

  Recorded model years: 2000

• PE02066 2002-09-06

  ENGINE STALL DUE TO FUEL STARVATION

  ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO…

  Recorded model years: 2000

• SQ01002 2001-01-26

  ERRATIC FUEL GAUGE

  There is no summary currently available

  Recorded model years: 2000

A further 8 records exist for the Pontiac Sunfire where the source stated no model year. They are not counted above and appear on no year page.

An investigation records that a regulator reviewed a suspected defect. It is not itself a finding of defect and not a recall.

Canada Recalls

Transport Canada Recall CA

• 2004033 2004-01-28

  Transport Canada recall 2004033

  On certain vehicles, if the engine fails to start and the driver holds the key in the "Start" position for an extended period, high current flowing through the ignition switch may produces enough heat to melt internal switch parts. If the switch is damaged, a fire could occur in the steering column, even with the engine off and the key…

  Recorded model years: 2000

• 2001096 2001-04-17

  Transport Canada recall 2001096

  Certain vehicles do not comply with the requirements of CMVSS 101- Location and Identification of Controls and Displays. Vehicles exhibit a condition in which the "Generator Low Voltage" indicator light will not illuminate under low voltage conditions. Correction: Dealers will reflash the vehicle PCM with new calibration software.

  Recorded model years: 2000

• 1999155 1999-08-19

  Transport Canada recall 1999155

  Certain vehicles may not comply with the requirements of CMVSS 101 - Control Location and Identification. The instrument panel backlighting may not function after adjusting the interior light intensity. If the instrument panel is not lit at night, the driver may not be able to see the controls and displays. Correction: Dealers will test the body control module (BCM) for…

  Recorded model years: 2000

A further 20 records exist for the Pontiac Sunfire where the source stated no model year. They are not counted above and appear on no year page.

Canadian campaigns are recorded separately from US campaigns and do not imply one another.

Consumer Complaints

NHTSA Complaint US

96 complaint records in the dataset for this vehicle and year.

Outcomes stated in those reports

• reports mentioning a crash 13
• reports mentioning a fire 5
• reported injuries 12
• reported fatalities 1

Outcomes as stated by the person who filed the report. They are not verified, not adjudicated, and carry no exposure denominator, so they cannot be turned into a rate.

By system

• Electrical system32 (19.0%)Official recall records for this system: 5, covering model years 1995–2001.
• Engine21 (12.5%)Official recall records for this system: 3, covering model years 1995–1999.
• Brakes20 (11.9%)
• Fuel system17 (10.1%)Official recall records for this system: 2, covering model years 1996–2002.
• Lights12 (7.1%)Official recall records for this system: 10, covering model years 1995–2003.
• Powertrain (transmission & drivetrain)11 (6.5%)Official recall records for this system: 1, covering model years 1995.
• Equipment & accessories10 (6.0%)
• Air bags (restraint system)9 (5.4%)Official recall records for this system: 2, covering model years 1996–1997.

Other / uncategorized: 2 classifications (1.2%) were not assigned to a specific system by the source. They are counted but not treated as an issue area.

A single report can name several systems, so these figures overlap and must not be added together — their sum is larger than the report total above.

A further 1,139 complaint records exist for this vehicle where the source stated no model year. They are not counted above and appear on no year page.

These are owner-submitted allegations, not confirmed defects. Counts are record counts in the dataset. No exposure denominator exists, so no failure rate or reliability score can be derived from them.