2004 Pontiac Sunfire
Documented records held locally from official US and Canadian sources. Each record shows its official identifier so it can be confirmed at the source; nothing here is a score or a prediction.
Vehicle coverage
Find your car
Choose a vehicle to see the official records held for it.
Coverage held for this vehicle
- OFFICIAL ACTION 2 US Recalls
- MANUFACTURER COMMUNICATION 461 Manufacturer Bulletins
- INVESTIGATION 0 Investigations
- CONSUMER REPORT 32 Consumer Complaints
- CANADIAN RECALL 1 Canada Recalls
These are counts of distinct official records held locally. They are not combined into any score, and a record count is not a failure rate. A zero means no record is held here, not that none exists.
US Recalls
NHTSA Recall US
-
08E063000 2008-10-17
Recall 08E063000
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE.…
Recorded model years: 2004
-
04V300000 2004-06-23
Recall 04V300000
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE PASSENGER-SIDE REAR SAFETY BELT MAY HAVE BEEN INSTALLED WITH AN INCORRECT NUT AND BOLT.
Recorded model years: 2004
A further 21 records exist for the Pontiac Sunfire where the source stated no model year. They are not counted above and appear on no year page.
Campaign applicability can depend on build date, equipment and market, and a remedy may already have been completed. Confirm any campaign against the official record using the VIN.
Manufacturer Bulletins
NHTSA Manufacturer Communication US
-
11020816 2025-07-18
PIP5601C
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
Recorded model years: 2004
-
11017252 2025-03-28
23-NA-001
This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
Recorded model years: 2004
-
11014455 2025-02-20
PIP5358D
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.
Recorded model years: 2004
Showing 3 of 461 records held. The full set is available from the official source named above.
A further 877 records exist for the Pontiac Sunfire where the source stated no model year. They are not counted above and appear on no year page.
A manufacturer communication is service guidance issued to dealers. It is not a safety recall, and its existence does not mean this vehicle has the described condition.
Investigations
NHTSA Investigation US
No matching records were found in the currently integrated dataset. This does not mean none exist for this vehicle — always check the official source using the VIN.
See all model years Go to the Pontiac Sunfire page
A further 8 records exist for the Pontiac Sunfire where the source stated no model year. They are not counted above and appear on no year page.
An investigation records that a regulator reviewed a suspected defect. It is not itself a finding of defect and not a recall.
Canada Recalls
Transport Canada Recall CA
-
2004211 2004-07-06
Transport Canada recall 2004211
Certain vehicles do not comply with the requirements of CMVSS 209 - Seat Belt Assemblies, and CMVSS 210 - Seat Belt Assembly Anchorages. On some of these vehicles, the passenger-side rear safety belt may have been installed with an incorrect nut and bolt that may not withstand the loads required by the two standards. In a severe crash, the upper…
Recorded model years: 2004
A further 20 records exist for the Pontiac Sunfire where the source stated no model year. They are not counted above and appear on no year page.
Canadian campaigns are recorded separately from US campaigns and do not imply one another.
Consumer Complaints
NHTSA Complaint US
32 complaint records in the dataset for this vehicle and year.
Outcomes stated in those reports
- reports mentioning a crash 3
- reports mentioning a fire 1
- reported injuries 1
Outcomes as stated by the person who filed the report. They are not verified, not adjudicated, and carry no exposure denominator, so they cannot be turned into a rate.
By system
- Electrical system16 (39.0%)Official recall records for this system: 5, covering model years 1995–2001.
- Engine6 (14.6%)Official recall records for this system: 3, covering model years 1995–1999.
- Brakes3 (7.3%)
- Lights3 (7.3%)Official recall records for this system: 10, covering model years 1995–2003.
- Body & structure3 (7.3%)Official recall records for this system: 3, covering model years 1995–1997.
- Equipment & accessories2 (4.9%)
- Air bags (restraint system)1 (2.4%)Official recall records for this system: 2, covering model years 1996–1997.
- Exhaust & emissions control1 (2.4%)Official recall records for this system: 2, covering model years 1996.
Other / uncategorized: 2 classifications (4.9%) were not assigned to a specific system by the source. They are counted but not treated as an issue area.
A single report can name several systems, so these figures overlap and must not be added together — their sum is larger than the report total above.
A further 1,139 complaint records exist for this vehicle where the source stated no model year. They are not counted above and appear on no year page.
These are owner-submitted allegations, not confirmed defects. Counts are record counts in the dataset. No exposure denominator exists, so no failure rate or reliability score can be derived from them.